Product ID:D-70 PENETRANT DEVELOPER
MSDS Date:10/01/1999
FSC:6850
NIIN:01-265-2742
Status Code:A
MSDS Number: CKPLZ

Emergency Phone: (800)424-9300

Info Phone: 310-450-1111

Preparer: NOT PROVIDED

Cage: 98733

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

ISOPROPANOL (2-PROPANOL)

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS: EYE CONTACT:
LIQUID CAUSES SEVERE IRRITATION, REDNESS, TEARING AND SWELLING OF
EYES. SKIN CONTACT: MAY CAUSE SKIN IRRITATION. PROLONGED OR
REPEATED CONTACT MAY DRY OUT THE SK IN DUE TO DEFATTING OF SKIN.
SYMPTOMS MAY INCLUDE REDNESS, BURNING, AND CRACKING OF SKIN.
SWALLOWING: SMALL AMOUNTS MAY NOT PRODUCE HARMFUL EFFECTS. LARGE
AMOUNTS MAY BE HARMFUL. INHALATION: SMALL AMO UNTS MAY NOT BE
HARMFUL. LARGE AMOUNTS MAY BE HARMFUL.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT KNOWN TO CONTAIN
ANY CONSTITUENTS IN REPORTABLE AMOUNTS LISTED AS CARCINOGENS BY THE
INTERNATIONAL AGENCY FOR RESEARCH FOR CANCER, THE NATIONAL
TOXICOLOGY PROGRAM OR OSHA.
Effects of Overexposure:STOMACH OR INTESTINAL UPSET (NAUSEA, VOMITING,
DIAHRREA), IRRITATION (NOSE, THROAT, AIRWAYS), CENTRAL NERVOUS
SYSTEM DEPRESSION (DIZZINESS, FATIGUE, HEADACHE, UNCONSCIOUSNESS).
Medical Cond Aggravated by Exposure:NOT PROVIDED

First Aid:EYES: FLUSH WITH CLEAN WATER FOR AT LEAST 15 MINUTES. HOLD
EYELIDS OPEN. SEEK MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH EXPOSED AREA WITH SOAP AND WATER. IF SYMPTOMS
PERSIST, SEEK ME DICAL ATTENTION. LAUNDER CLOTHING BEFORE REUSE.
CLEAN SHOES BEFORE REUSE. SWALLOWING: CALL A PHYSICIAN IMMEDIATELY.
IF INDIVIDUAL IS DROWSY OR UNCONSCIOUS, DO NOT GIVE ANYTHING BY
MOUTH; PLACE INDIVID UAL ON THEIR LEFT SIDE WITH THE HEAD DOWN. DO
NOT LEAVE THE INDIVIDUAL UNATTENDED. INHALATION: REMOVE TO FRESH
AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGE N. GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=11.7C, 53.F
Autoignition Temp:=398.9C, 750.F
Lower Limits:2.0%
Extinguishing Media:DRY CHEMICAL, ALCOHOL FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SPRAY MAY BE
USED TO KEEP FIRE EXPOSED CONTAINERS COOL. WEAR FULL PROTECTIVE
CLOTHING AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACE PIECE OPERATE D IN THE PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND TO DISTANT IGNITION SOURCE AND FLASH BACK.
SEALED CONTAINERS MAY RUPTURE WHEN HEATED.

Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. ISOLATE HAZARD AREA. WEAR PROTECTIVE GEAR, KEEP
UNNECESSARY PERSONNEL AWAY. CONTAIN AND RECOVER LIQUID WHEN
POSSIBLE. USE NON-SPARKING TOOLS. COLLECT LI QUID IN AN APPROPRIATE
CONTAINER AND ABSORB WITH AN INERT MATERIAL SUCH AS VERMICULITE,
DRY SAND OR EARTH; DO NOT USE COMBUSTIBLE MATERIALS. PLACE IN A
CHEMICAL WASTE CONTAINER. DO NOT FLUSH TO SEWER!
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE. STORE
IN A COOL, DRY WELL-VENTILATED LOCATION, AWAY FROM AREAS WHERE FIRE
HAZARD OR IGNITION SOURCES MAY EXIST. OUTSIDE OR DETACHED STORAGE
IS PREFERRED. CONTAINERS SH OULD BE GROUNDED FOR TRANSFERS TO AVOID
STATIC SPARKS. STORE AND USE IN NOT SMOKING AREA.
Other Precautions:CONTAINER MAY BE HAZARDOUS WHEN EMPTY SINCE RESIDUE
LIQUID AND VAPORS MAY BE PRESENT. USE NONSPARKING TOOLS. ANY USE OF
THIS PRODUCT IN ELEVATED TEMPERATURE PROCESSING SHOULD BE
THOROUGHLY EVALUATED T O ESTABLISH AND MAINTAIN SAFE OPERATING
CONDITIONS.

Respiratory Protection:PERSONAL RESPIRATORS (NIOSH APPROVED) IF
EXPOSURE LIMIT IS EXCEEDED.
Ventilation:A SYSTEM OF LOCAL OR GENERAL EXHAUST IS RECOMMENDED TO KEEP
EMPLOYEE EXPOSURE BELOW THE AIRBORNE EXPOSURE LIMITS.LOCAL EXHAUST
VENTILATION IS PREFERRED.
Protective Gloves:WEAR RESISTANT GLOVES.
Eye Protection:CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA
REGULATIONS ARE ADVISED.
Other Protective Equipment:EYE WASH AND QUICK-DRENCH FACILITIES SHOULD
BE NEAR WORK AREA. TO PREVENT REPEATED OR PROLONGED SKIN CONTACT,
WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
NONE

HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=82.2C, 180.F
Vapor Pres:33.0MMHG@68F
Vapor Density:2.07
Spec Gravity:0.8565
VOC Pounds/Gallon:710
pH:NO DATA
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:1.7 (N-BUTYL ACETATE=1)
Solubility in Water:90%
Appearance and Odor:WHIRE, MILKY SUSPENSION IN LIQUID; SLIGHT
ETHANOL/ACETONE LIKE ODOR.
Percent Volatiles by Volume:90
Corrosion Rate:NOT PROVIDED

Stability Indicator/Materials to Avoid:YES
DO NOT USE WITH ALUMINUM EQUIPMENT AT TEMPERATURES ABOVE 120 F.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE &
STORAGE.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE AND CARBON
MONOXIDE.

Waste Disposal Methods:PROCESSING, USE OR CONTAMINATION OF THIS PRODUCT
MAY CHANGE THE WASTE MANAGEMENT OPTIONS. STATE AND LOCAL DISPOSAL
REGULATIONS MAY DIFFER FROM FEDERAL DISPOSAL REGULATIONS. DISPOSE
OF CONTAINER AND UN USED CONTENTS IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGUIREMENTS. NOTE: MSDS INFORMATION IS FO R AS SUPPLIED
LIQUID.

Toxicological Information:NO DATA.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA AVAILABLE ON PRODUCT.

Transport Information:DOT INFORMATION - 49CFR 172.101 SHIPPING NAME:
ISOPROPANOL. LABEL: FLAMMABLE LIQUID. HAZARD CLASS: 3.
INDENTIFICATION NUMBER: UN1219. PACKING GROUP: I I. REPORTABLE
QUANTITY - 49 CFR 172.101 - NOT AP PLICABLE.

SARA Title III Information:SARA 302 COMPONENTS- 40 CFR 355 APPENDIX A:
NONE. SARA SECTION 311/312 HAZARD CLASS- 40 CFR 370.2: IMMEDIATE X,
DELAYED X, FIRE X, REACTIVE NO, SUDDEN RELEASE OF PRESSURE NO. SARA
313 COMPONENTS- 40 C FR 372.2: NONE. CERCLA RQ- 49 CFR 302(A): NONE
LISTED.
Federal Regulatory Information:TSCA: LISTED.
State Regulatory Information:CALIFORNIA PROPOSITION 65 REQUIRES
FOLLOWING STATEMENT: PRODUCT MAY CONTAIN DETECTABLE AMOUNTS OF
SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER. NEW
JERSEY RTK LABEL- ISOPROPYL ALCOHOL 6 7-63-0. PENNSYLVANIA RTK
LABEL- 2-PROPANOL 67-63-0.